Volatile fatty acids production from fermentation of secondary sewage sludge : a thesis presented in partial fulfillment of the requirements for the degree of Master of Engineering in Environmental Engineering
Loading...
Date
2008
DOI
Open Access Location
Authors
Journal Title
Journal ISSN
Volume Title
Publisher
Massey University
Rights
The Author
Abstract
Sludge fermentation is used worldwide as an economical means to produce volatile fatty acids (VFA), which can be used as readily available carbon in biological nutrient removal (BNR) systems. In this research, secondary sludge was tested for its potential to generate VFA. Fermentation of secondary sludge was carried out in a lab-scale sequencing batch reactor (SBR). The SBR was fed with secondary sludge of 1% total solids and run with hydraulic retention time (HRT) of 48 hours and 28 hours in phase 1 (40 days) and phase 2 (12 days) respectively. The SBR produced net VFA (expressed as acetic acid) of 365 ±62.5 mg VFA
HAC
/I which was equivalent to a VFA yield of 0.28 ±0.05 mg VFA
HAC
/mg VSS
feed
during phase 1. A change in operating HRT from 48 hours to 28 hours led to a reduction in solids retention time (SRT) from 2.65 days to 2 days in phase 2. The reduction in SRT during phase 2 led to poor hydrolysis and hence could not support the fermentation. Net VFA generation decreased during phase 2 and reached 0 mg/I. Acetic acid was the main acid produced comprising 45% of total VFA content during the run with 48 hours HRT. The effect of total solids (TS) concentration on secondary sludge fermentation was tested using batch experiments. The batch with 2.8% TS secondary sludge showed a maximum net VFA production of 60 mg VFA
HAC
/I, which appeared to be superior to the 1% TS secondary sludge batch fermentation where no net VFA production observed throughout the test period. Primary sludge (3% TS) exhibited 1200 mg VFA
HAC
/I in a batch fermentation, which was superior to the net VFA produced during secondary sludge (2.8% TS) batch fermentation. The effects of sonication on fermentability of primary and secondary sludges were tested. A sonic power application of 0.0017 Watt/ml/min density increased soluble content of primary and secondary sludges. In batch fermentations, sonicated secondary sludge improved fermentation over unsonicated secondary sludge. A maximum net VFA production of 130 mg VFA
HAC
/I was observed in the secondary sludge batch fermentation. In this research work, an investigation into inhibiting VFA degradation in secondary sludge batch fermentations was also carried out. The effects of a methanogenic bacteria inhibitor (bromoethane sulfonic acid) and low pH (range of 4.02-6.07) were considered. The addition of 1 mM bromoethane sulfonic acid (BES) in secondary sludge (1% TS) batch fermentation successfully inhibited VFA degradation. pH values as low as 4.02 showed an inhibitory effect on secondary sludge (1% TS) batch fermentation which led to poor hydrolysis and hence no net VFA generated during the test period. However, low pH values reduced the VFA degradation rate in the batch fermentations. Secondary sludge used in the present research showed the potential to generate VFA. The amount of VFA produced in the present work showed the potential to improve the performance of a BNR system. Moreover, in batch fermentations, VFA generation was improved using various pre-treatments like sonication and BES addition.
Description
Keywords
Sewage sludge -- Analysis, Fatty acids, Sewage -- Purification -- Nutrient removal