A study of drying, threshing and storage conditions on the viability of soybean seeds with a supplementary study of the efficiency of a simple drying method developed : a thesis presented in partial fulfilment of the requirements for the degree of Master of Agricultural Science in Seed Technology at Massey University

Thumbnail Image
Open Access Location
Journal Title
Journal ISSN
Volume Title
Massey University
The Author
This study was designed to investigate the relevance of postharvest factors in maintaining the viability and storability of soybean seeds. In order to obtain high quality seeds for the drying and storage aspects of the experiment, the sequence of seed development and physiological maturity of the crop was investigated to ascertain maximum viable seed yield. The soybean cultivar 'V-53' was sown and plants were randomly sampled at 32 days after peak flowering, and subsequently every 5 days until the seeds reached physiological maturity. The changes in seed moisture content, fresh weight, dry weight, percent germination and maximum viable seed yield in relation to time after peak flowering were measured. The soybean crop achieved a maximum viable seed yield of 1344. 1 kg/ha 77 days after peak flowering. The development of the crop was prolonged by adverse weather conditions. After soybean seeds reached physiological maturity, the crop was harvested at a seed moisture content of 49.2% and germination of 96%. Further studies were carried out to investigate those factors that affect seed viability before and during storage. The drying effect on seed viability was made by comparing the effect of 6 different drying methods i.e. dehumidification, refrigeration, ambient air and heated air at 30°C, 40°C or 50°C. Seeds were dried to 8% moisture content in each case. Delays between harvest and the commencement of drying operations result in a decline of seed germinability, particularly in seedlot which was later used in the refrigeration drying system. Although drying method had no immediate effect on seed viability during drying, drying seed by refrigeration method was time consuming the drying rate being too slow and resulting in subsequent seed deterioration. The heated air methods were most efficient in assisting removal of moisture from the seed. Following drying, seeds were threshed from the pods by hand threshing or beating threshing methods. Seeds from different drying and threshing treatments were stored under 20°C - 40%RH or 35°C - 90%RH conditions for 16 weeks. The threshing of seed using a beating method caused a significant reduction in seed germinability when compared to the hand system used to remove seed from the pod. Drying method had no significant effect on seed storability when seeds were stored under good storage conditions i.e. 20°C - 40%RH. However, when seeds were stored under poor storage conditions i.e. 35°C - 90%RH, seeds previously dried at 40°C and 50°C using heated air showed a more severe drop in germination after only 2 weeks when compared to seeds dried by 30°C heated air. The effect of unheated air on seed storability was possibly not detected since there was wide variation in the results and the storage conditions of 35°C - 90%RH had severely affected seed viability after only 4 weeks storage. Seeds stored under 35°C - 90%RH conditions rapidly gained moisture to a relatively high level. This high moisture content in seeds accelerated the rate of deterioration and favoured the growth of storage fungi which were greatly responsible for loss of viability. Although there was a reduction in the germination capacity of seed stored under 20°C - 40%RH conditions after 16 weeks, these conditions were vastly superior to storage conditions of 35°C - 90%RH. In the present study, the effect of drying method was not as important as storage conditions in maintaining seed viability. However, with proper harvesting, drying and threshing the problems of maintaining high level of seed viability could be eliminated. A separate drying experiment was carried out to evaluate the possible use of the 'Kiwi' drier and its efficiency in drying various seed crops. The 'Kiwi' drier was designed at the Seed Technology Centre and consists of a cylindrical metal drum containing 2 metal tubes filled with silica gel as a dessicant. As presently constructed the drier resulted in very slow and inefficient drying of barley, pea and Tama ryegrass seeds. However, results suggest that by redesigning certain features in the 'Kiwi' drier to improve air circulation and increase the area of close contact between the silica gel and the seeds it's seed drying efficiency could be greatly improved. In addition, the 'Kiwi' drier provides an ideal storage container for seeds in tropical climates.
Drying apparatus, Soybean, Seeds -- Harvesting, Seeds -- Storage